SYNTHESIS AND INVESTIGATION OF PROPERTIES OF COMPOSITE CERAMICS LuAG: Ce / Al2O3

Cover Page

Cite item

Full Text

Abstract

The purpose of this work was to study the effect of the aluminum oxide impurity content on the features of vacuum sintering, optical and luminescent properties of composite ceramics LuAG : Ce / Al 2 O 3. Ceramic powders LC -1, LC -2, LC -3 of the composition Lu 2,98 Ce 0,02 Al 5 O 12 / Al 2 O 3 were synthesized, where the corundum content was 0, 10, 20 wt.% respectively. The dynamics of shrinkage of ceramic compacts by dilatometry, morphology and elemental analysis of the surface of sintered ceramics LuAG are investigated: Ce / Al 2 O 3 - by scanning electron microscopy. Light transmission and luminescence spectra were obtained. It is shown that with an increase in the content of corundum in the composition of ceramic powder, the temperatures of the beginning and end of shrinkage increase. In this case, the residual porosity is concentrated in areas of ceramics containing mainly corundum crystallites, as a material with a higher sintering temperature. It was revealed that the inclusion of the corundum phase prevents the uncontrolled growth of ceramic grains. Composition with a corundum content of 10 wt.% showed the highest value of luminescence intensity. At the same time, with an increase in the proportion of corundum in composite ceramics, a slight broadening of the luminescence spectra was observed.

About the authors

Viacheslav A. Lapin

North Caucasus Federal University

Email: viacheslavlapin@yandex.RUS
Stavropol, Russia

Alexander A. Kravtsov

North Caucasus Federal University

Stavropol, Russia

Victoria E. Suprunchuk

North Caucasus Federal University

Stavropol, Russia

Ludmila V. Tarala

North Caucasus Federal University

Stavropol, Russia

Evgeniy V. Medyanik

North Caucasus Federal University

Stavropol, Russia

Fedor F. Malyavin

North Caucasus Federal University

Stavropol, Russia

References

  1. Liu, I. 50 mm-aperture Nd:LuAG ceramic nanosecond laser amplifier producing 10 J at 10 Hz / I. Liu, T. Feng, Z. Sui et al. // Optics Express. - 2019. - V. 27. - I. 11. - P. 15595-15603. doi: 10.1364/OE.27.015595.
  2. Chen, X. Influence of cerium doping concentration on the optical properties of Ce, Mg: LuAG scintillation ceramics / X. Chen, Z. Hu, M. Cao et al. // Journal of the European Ceramic Society. - 2018. - V. 38. - I. 9.- P. 3246-3254. doi: 10.1016/j.jeurceramsoc.2018.03.023.
  3. Zhang, Y. Pore-existing Lu3Al5O12:Ce ceramic phosphor: An efficient green color converter for laser light source / Y. Zhang, S. Hua, Z. Wanga, G. Zhoua, S. Wanga // Journal of Luminescence. - 2018. - V. 197.- P. 331-334. doi: 10.1016/j.jlumin.2018.01.014.
  4. Hu, S. Transparent YAG: Ce ceramics for WLEDs with high CRI: Ce 3+ concentration and sample thickness effects / S. Hu, C. Lu, G Zhou et al. // Ceramics International. - 2016. - V. 42. - I. 6. - P. 6935-6941. doi: 10.1016/j.ceramint.2016.01.079.
  5. Lago, M.D. Phosphors for LED-based light sources: thermal properties and reliability issues / M.D. Lago, M. Meneghini, N. Trivellin et al. // Microelectronics Reliability. - 2012. - V. 52. - I. 9-10. - P. 2164-2167. doi: 10.1016/j.microrel.2012.06.036.
  6. Zhao, C. Synthesis and luminescence properties of color-tunable Ce, Mn co-doped LuAG transparent ceramics by sintering under atmospheric pressure / C. Zhao, Y. Duan, H. Lin, et al. // Ceramics International.- 2020. - V. 47. - I. 7. - P. 9156-9163. doi: 10.1016/j.ceramint.2020.12.040.
  7. Kim, H.T. Green light-emitting Lu3Al5O12:Ce phosphor powders prepared by spray pyrolysis / H.T. Kim, J.H. Kim, J.-K. Lee, Y.C. Kang // Materials Research Bulletin. - 2012. - V. 47. - I. 6. - P. 1428-1431. doi: 10.1016/j.materresbull.2012.02.050.
  8. Кравцов, А.А. Исследование люминесценции YAG:Ce, допированного наночастицами серебра / А.А. Кравцов, И.С. Чикулина, Д.С. Вакалов и др. // Физико-химические аспекты изучения кластеров, наноструктур и наноматериалов. - 2021. - Вып. 13. - С. 220-227. doi: 10.26456/pcascnn/2021.13.220.
  9. Mares, J.A. Time development of scintillating response in Ce- or Pr-doped crystals / J.A. Mares, A. Beitlerova, M. Nikl et al. // Physica Status Solidi (C). - 2007. - V. 4. - I. 3. - P. 996-999. doi: 10.1002/pssc.200673858.
  10. Shi, Y. Dense Ce3+ doped Lu3A15O12 ceramic scintillators with low sintering adds: Doping content effect, luminescence characterization and proton irradiation hardness / Y. Shi, Y. Zhao, M. Cao et al. // Journal of Luminescence. - 2020. - V. 225. - Art. № 117336. - 7 p. doi: 10.1016/j.jlumin.2020.117336.
  11. Kim, S. Pore characteristics for improving luminous efficacy of phosphor-in-glass / S. Kim, H. Yie, S. Choi et al. // Optics Express. - 2015. - V. 23. - I. 24. - P. A1499-A1511. doi: 10.1364/OE.23.0A1499.
  12. Bechtel, H. Lumiramic: a new phosphor technology for high performance solid state light sources / H. Bechtel, P. Schmidt, W. Busselt, B.S. Schreinemacher // Proceedings of SPIE, Eighth International Conference on Solid State Lighting, 2 September 2008, San Diego. - 2008. - V. 7058. - Art. id. 70580E, - 10 p. doi: 10.1117/12.794941.
  13. Powder Diffraction File JCPDS-ICDD PDF-2 (Set 1-47). (Release, 2016). - Режим доступа: www.url: https://www.icdd.com/pdf-2. - 15.06.2023.
  14. Kravtsov, A.A. Nucleation and growth of YAG: Yb crystallites: A step towards the dispersity control / A.A. Kravtsov, I.S. Chikulina, V.A. Tarala et al. // Ceramics International. - 2020. - V. 46. - I. 18. - P. 28585-28593. doi: 10.1016/j.ceramint.2020.08.016.
  15. Антонов, Д.А. Корундовая керамика для мелющих тел с пониженной температурой спекания / Д.А. Антонов, С.С. Павлов, Н.А. Макаров // Современные методы и технологии создания и обработки материалов. - 2018. - Вып. 1. - С. 12-21.
  16. Zhou, C. Synthesis, sintering and characterization of porous nano-structured CaP bioceramics prepared by a two-step sintering method / C. Zhou, P. Xie, Y. Chen et al. // Ceramics International. - 2015. - V. 41. - I. 3.- P. 4696-4705. doi: 10.1016/j.ceramint.2014.12.018.
  17. Al-Aqeeli, N. The synthesis of nanostructured WC-based hardmetals using mechanical alloying and their direct consolidation / N. Al-Aqeeli, N. Saheb, T. Laoui, K. Mohammad // Journal of Nanomaterials. - 2014.- V. 2014. - Art. id. 640750. - 16 p. doi: 10.1155/2014/640750.
  18. Fang, M.-H. Control of narrow-band emission in the phosphor materials for the application in light-emitting diodes / M.-H. Fang, J.L. Leano, R.-S. Liu // ACS Energy Letters. - 2018. - V. 3. - I. 10. - P. 2573-2586. doi: 10.1021/acsenergylett.8b01408.

Supplementary files

Supplementary Files
Action
1. JATS XML
Download

Согласие на обработку персональных данных

 

Используя сайт https://journals.rcsi.science, я (далее – «Пользователь» или «Субъект персональных данных») даю согласие на обработку персональных данных на этом сайте (текст Согласия) и на обработку персональных данных с помощью сервиса «Яндекс.Метрика» (текст Согласия).